GOLFMK8
GOLFMK7
GOLFMK6
GOLFMKV

MK5 GTI EVAP Emission Control Sys P0441 - 002 - Incorrect Flow - Intermittent

Scuba

New member
Location
Beirut
Hello Everybody

i am receiving the below error on my GTI 2007 after clearing the error in less than 1 day it come back again .
i did the output test of the N80 i can hear it properly so any other part to check ,as i cant find any leak

1 Fault Found:

001089 - EVAP Emission Control Sys
P0441 - 002 - Incorrect Flow - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 1
 
Location
Pikeville, KY
Car(s)
Subaru
i have a p0442 and p0455 sometimes. i have replaced the n80 and that didnt help. there are a few hoses that are around there and a canister too. try taking the hoses off and blowing through them to see if theyre are clogged up. also, it could be as simple as a bad gas cap seal

ive had my errors for 2yrs. good luck
 

Spectre

Ready to race!
Location
Atlanta
can you point me in the direction on how to do this. id like to do it too

Sure. Once I figure it out I will. It can be done. My TT/1.8T buddy does it to all his cars. I've capped off the purge valve inlet which eliminates EVAP. Now I just have to remove what's not necessary.
 

mfractal

Ready to race!
Location
Brazil
In my experience replacing the canister resolves the P0441 error 99% of teh times.
I do wish there was a DIY on EVAP delete!

Tapatalkin'
 

eurocars

5/17/15 - Never forget
Location
Indianapolis
Car(s)
2006 GTI
16825/P0441/001089 - EVAP Emission Control Sys: Incorrect Flow

Possible Causes

Evaporative Emission (EVAP) Canister Purge Regulator Valve (N80) faulty/jammed
Evaporative Emission (EVAP) Canister Purge Solenoid Valve (N115) faulty/jammed
Evaporative Emission (EVAP) Canister Sealing faulty
Pipes between Tank Breathing and Throttle Body leaky/blocked

Possible Solutions

Check Evaporative Emission (EVAP) Canister Purge Regulator Valve (N80)
Perform Output Test
Check Evaporative Emission (EVAP) Canister Purge Solenoid Valve (N115)
Check Evaporative Emission (EVAP) Canister
Perform Basic Setting
Check Pipes between Tank Breathing and Throttle Body
 

Spectre

Ready to race!
Location
Atlanta
My car had an EVAP leak and I unplugged it at the purge valve and out ran fine. I'm tracing it back from there and plugging it where need be and removing everything I can.

Fortunately I don't have emissions.n
 

ninohale

Dub 2.0
Location
Cincinnati
Car(s)
'06 MKV BMP
I've had this code for 2 years.... When you clear it does it start with a check gas cap warning?

Everything in my EVAP system has been replaced but the EVAP canister. Just haven't felt like messing with it.

I wish you the best if you try and delete the EVAP system from a MKV. Going to be a pain!
 
Top